Product ID:INTERPROTECT HIGH SOLIDS, Y3001
MSDS Date:12/19/1996
FSC:8010
NIIN:00N091499
Status Code:A
MSDS Number: CJPDN

COURTAULDS COATINGS INC

6001 ANTOINE DRIVE
HOUSTON, TX 77091
US

Emergency Phone: 800-854-6813

Info Phone: 713-684-1563

Cage: 028S6

INTERNATIONAL PAINT INC

HOUSTON, TX 77091 US

Telephone: 713-684-1244

Cage: 028S6

ALKYL (C12-C14) GLYCIDYL ETHER

CAS: 68609-97-2

OSHA PEL N/K

ACGIH TLV: N/K

N-BUTYL ALCOHOL

CAS: 71-36-3

RTECS: EO1400000

OSHA PEL 300 MG/M3;100 PPM

ACGIH TLV: N/K

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

BENZYL ALCOHOL

CAS: 100-51-6

RTECS: DN3150000

OSHA PEL N/K

ACGIH TLV: N/K

TRIMETHYLHEXAMETHYLENEDIAMINE

CAS: 25620-58-0

OSHA PEL N/K

ACGIH TLV: N/K

PHENOL

CAS: 108-95-2

RTECS: SJ3325000

OSHA PEL 19 MG/M3;5 PPM

ACGIH TLV: 19 MG/M3;5 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

DIETHYLENETRIAMINE

CAS: 111-40-0

RTECS: IE1225000

OSHA PEL 1 PPM

ACGIH TLV: 4.2 MG/M3;1 PPM

STODDARD SOLVENT; (MINERAL SPIRITS)

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 2900 MG/M3;500 PPM

ACGIH TLV: 525 MG/M3;100 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: CAUSES NOSE AND THROAT
IRRITATION. HARMFUL IF INHALED. MAY AFFECT THE BRAIN OR NERVOUS
SYSTEM CAUSING DIZZINESS, HEADACHE OR NAUSEA. EYES: CAUSES SEVERE
IRRITATION. SKIN: CAN BE ABSORBED T HROUGH THE SKIN. MAY CAUSE
ORGAN DAMAGE. CAUSES SEVERE IRRITATION. INGESTION: POISON BY
INGESTION. INGESTION CAN CAUSE GANGRENE AND CORROSION OF THE LIPS,
MOUTH, THROAT, ESOPHAGUS, AND STOMACH.
Effects of Overexposure:SEE HEALTH HAZARDS.

First Aid:GENERAL: IN ALL CASES OF DOUBT/WHEN SYMPTOMS PERSIST, SEEK
MEDICAL ATTN. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. INHALATION: REMOVE TO FRESH AIR. IF DISCOMFORT IS
PRESENT/BREATHING IS A BSENT, GET MEDICAL ATTENTION IMMEDIATELY.
EYES: FLUSH IMMEDIATELY W/PLENTY OF WATER FOR AT LEAST 15 MINUTES,
UNTIL IRRIT SUBSIDES. IF IRRIT PERSISTS, GET MEDICAL ATTENTION.
SKIN: FLUSH W/LARGE AMOUNT OF WATER. USE SOAP IF AVAILABLE. REMOVE
SEVERELY-CONTAMINATED CLOTHING (INCLUDING SHOES) & WASH BEFORE
REUSE. IF IRRIT PERSISTS, GET MEDICAL ATTENTION. INGESTION: IF
SWALLOWED, DO NOT INDUCE VOMITING. KEEP AT REST. GET PROMPT
MEDICAL ATTN.

Flash Point:=51.7C, 125.F
Lower Limits:0.6%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:OSHA CLASSIFICATION: COMBUSTIBLE
LIQUID-CLASS II. ISOLATE FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT &
OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME
HEAT. IN ABSENCE OF ELECTRICITY, A WATER SPRAY (FOG NOZZLE IS
PREFERRED) MAY BE USED TO COOL CONTAINERS. DECOMPOSITION &
COMBUSTION PRODUCTS MAY BE TOXIC.

Spill Release Procedures:CONTAIN SPILLED LIQUID WITH SAND OR EARTH. DO
NOT USE COMBUSTIBLE MATERIALS SUCH AS SAWDUST. ABSORB SPILL WITH AN
INERT MATERIAL (E.G., DRY SAND OR EARTH), THEN PLACE IN A CHEMICAL
WASTE CONTAINER.

Handling and Storage Precautions:KEEP CONTAINER CLOSED. LOOSEN CLOSURE
CAUTIOUSLY BEFORE OPENING. STORE IN A COOL, WELL-VENTILATED PLACE,
AWAY FROM INCOMPATIBLE MATERIALS. (SEE STABILITY AND REACTIVITY
SECTION.) KEEP AWAY FROM HEAT, SPARKS AND FLAMES. PROTECT MATERIAL
FROM DIRECT SUNLIGHT.
Other Precautions:GROUND AND BOND CONTAINERS WHEN TRANSFERRING
MATERIALS. EMPTY CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES. FOLLOW
ALL MSDS/LABEL WARNINGS, EVEN AFTER THE CONTAINER IS EMPTIED.

Respiratory Protection:USE A RESPIRATOR APPROVED BY NIOSH AND IN
ACCORDANCE WITH 29 CFR 1910.134 TO REMOVE PARTICULATES (AND VAPORS
IF THERE IS OVEREXPOSURE TO VAPORS GENERATED DURING THE PROCESSING
OF THIS PRODUCT).
Ventilation:PROVIDE SUFFICIENT VENT, IN VOL & PATTERN, TO: A) KEEP TLV
OF HAZ INGS BELOW LIMS SPECIFIED; B) REMOVE VOLATILES PRDCED DURING
CURE & DECOMP PRODS (SUP DAT)
Protective Gloves:WEAR CHEMICAL-RESISTANT GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES AND FULL LENGTH
FACESHIELD .
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . AS NEEDED, USE BODY PROTECTION TO AVOID CONTACT
WITH PRODUCT.
Supplemental Safety and Health
VENT: PRODUCED DURING WELDING/CUTTING ON SURFACES COATED W/THIS PROD.

Boiling Pt:=117.2C, 243.F
Vapor Density:HVR/AIR
Spec Gravity:0.959
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. FUMES MAY PRODUCE CARBON
DIOXIDE AND CARBON MONOXIDE.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.

Toxicological Information:THERE IS NO DATA AVAILABLE ON THE PRODUCT
ITSELF. ABSORPTION THROUGH THE SKIN CAN CAUSE DAMAGE TO THE LIVER,
KIDNEYS, PANCREAS, AND SPLEEN AND SWELLING OF THE LUNGS. CHRONIC
EXPOSURE CAN CAUSE DEATH. SYMPTOMS OF EXPOSURE INCLUDE: VOMITING,
DIFFICULTY IN SWALLOWING, DIARRHEA, NAUSEA, FAINTING, DIZZINESS,
PALE SKIN, COLD SWEAT. NOTICE: REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVER EXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:THERE IS NO DATA AVAILABLE ON THE PRODUCT ITSELF.

Transport Information:DOT (DEPARTMENT OF TRANSPORTATION): PROPER
SHIPPING NAME: PAINT; HAZARD CLASS: COMBUSTIBLE (NOT SUBJECT TO CFR
49, REF 173.150(F), NMFC 149980); UN NUMBER: NOT REGULATED; PACKING
GROUP: NOT REGULATED.

SARA Title III Information:SARA TITLE III (SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT): NONE KNOWN UNLESS CHEMICALS ARE SPECIFIED
BELOW. SECTION 302 REPORTABLE INGREDIENTS: PHENOL, CAS # 108-95-2.
313 REPORTABLE INGREDIENTS: N-BUTYL ALCOHOL, CAS # 71-36-3;
PHENOL, CAS # 108-95-2.
Federal Regulatory Information:TSCA (TOXIC SUBSTANCE CONTROL ACT):
COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY. CERCLA
(COMPREHENSIVE RESPONSE COMPENSATION, AND LIABILITY ACT):
MANUFACTURER RECOMMENDS YOU CONTACT LO CAL AUTHORITIES TO DETERMINE
IF THERE MAY BE OTHER LOCAL REPORTING REQUIREMENTS.
State Regulatory Information:NONE KNOWN UNLESS SPECIFIED BELOW.